At some point, the worker lost consciousness due to the oxygen deficient atmosphere in the confined space and fell 40 ft., then drowned in a foot of water.
“Cal/OSHA launched a confined space educational program to bring attention to the dangers and preventable deaths that occur in confined spaces,” said Cal/OSHA Chief Juliann Sum in a statement. “The program helps employers identify hazards and create effective safety plans that include air monitoring, rescue procedures and training before work begins.”
General contractor Tyler Development was constructing a single-family residence in the Bel Air area and hired subcontracted D&D Construction to install and service reinforced concrete posts known as caissons on the property, according to the agency’s report.
The state-run occupational safety unit cited Tyler Development and D&D Construction Specialties Inc. a combined $352,570 for ten serious and willful health and safety violations following an investigation. Cal/OSHA said neither company was in compliance with required confined space procedures.
D&D Construction previously was cited in 2012 for similar safety violations at a different job site.
In total, D&D has to pay a proposed $337,700 for 13 violations, including two willful serious accident-related, one willful serious, one serious accident-related, six serious, and three general in nature.
According to Cal/OSHA, the company failed to:
• ensure safe entry into the confined space
• have an effective method to rescue the worker in the confined space in an emergency
• test the environment to determine if additional protective equipment, such as a respirator or oxygen tank, were required to work safely in the shaft.
Tyler Development was cited $14,870 for five violations, three of them serious, for a failure to:
• evaluate the worksite for possible permit-required confined spaces
• ensure that the subcontractor meets all requirements to comply with a permit space program
• protect workers from the hazard of impalement by guarding all exposed reinforced steel ends that extend up to six feet above the work surface with protective covers
A full copy of the report is available here.